Casein probe–based fast plasmin determination in the picomolar range by an ultra-high frequency acoustic wave biosensor

Loránd Románszki, Marek Tatarko, Mengchi Jiao, Z. Keresztes, Tibor Hianik, Michael Thompson

Research output: Contribution to journalArticle

3 Citations (Scopus)

Abstract

Detection of residual plasmin activity in milk represents a difficult challenge for the dairy industry. Conventional methods are either too expensive or incapable of providing enough data from UHT treated milk. Acoustic wave–based biosensors operated in the thickness shear mode (TSM) showed potential for the detection of proteolysis of β-casein, a milk protein by protease plasmin. An ultra-high frequency device, the electromagnetic piezoelectric acoustic sensor (EMPAS), designed to enhance the sensitivity of TSM, was tested for detection of plasmin at low concentrations. β-casein layers immobilised on the hydrophilic or hydrophobized surfaces of EMPAS quartz discs served as substrate for the enzyme. In contrast with conventional TSM devices, the shearing oscillations in EMPAS are induced contactless, by a magnetic coil located 30 μm below the quartz crystal. This configuration allows the registration of unusually high harmonics (up to the 49th-53rd), thus enhancing the sensitivity of detection. On both surface types, the adsorbed β-casein mass and the stability of the layer was compared, with the result that hydrophobic surfaces provide superior conditions for immobilisation than the hydrophilic case. Consequent proteolysis measurements of these substrate layers were carried out in a broad plasmin concentration range (32 pM–10 nM) in flow mode. Initial reaction rates measured at different enzyme concentrations have been used to construct a calibration curve based on an inverse Michaelis–Menten type equation. The sensitivity of the EMPAS allowed measurements of as low as 32 pM concentration of plasmin, reaching (and often exceeding) levels comparable to state of the art techniques like ELISA. The presented method however, unlike ELISA, is effective on a timescale of minutes.

Original languageEnglish
Pages (from-to)206-214
Number of pages9
JournalSensors and Actuators, B: Chemical
Volume275
DOIs
Publication statusPublished - Dec 1 2018

Fingerprint

Casein
Fibrinolysin
ultrahigh frequencies
Caseins
bioinstrumentation
Biosensors
Acoustics
Acoustic waves
milk
acoustics
Proteolysis
electromagnetism
Quartz
sensors
Sensors
shear
UHF devices
enzymes
Enzymes
magnetic coils

Keywords

  • Electromagnetic piezoelectric acoustic sensor
  • Inverse Michaelis–Menten equation
  • Plasmin
  • β-casein

ASJC Scopus subject areas

  • Electronic, Optical and Magnetic Materials
  • Instrumentation
  • Condensed Matter Physics
  • Surfaces, Coatings and Films
  • Metals and Alloys
  • Electrical and Electronic Engineering
  • Materials Chemistry

Cite this

Casein probe–based fast plasmin determination in the picomolar range by an ultra-high frequency acoustic wave biosensor. / Románszki, Loránd; Tatarko, Marek; Jiao, Mengchi; Keresztes, Z.; Hianik, Tibor; Thompson, Michael.

In: Sensors and Actuators, B: Chemical, Vol. 275, 01.12.2018, p. 206-214.

Research output: Contribution to journalArticle

Románszki, Loránd ; Tatarko, Marek ; Jiao, Mengchi ; Keresztes, Z. ; Hianik, Tibor ; Thompson, Michael. / Casein probe–based fast plasmin determination in the picomolar range by an ultra-high frequency acoustic wave biosensor. In: Sensors and Actuators, B: Chemical. 2018 ; Vol. 275. pp. 206-214.
@article{b556df828212457692c8e6706f58d39a,
title = "Casein probe–based fast plasmin determination in the picomolar range by an ultra-high frequency acoustic wave biosensor",
abstract = "Detection of residual plasmin activity in milk represents a difficult challenge for the dairy industry. Conventional methods are either too expensive or incapable of providing enough data from UHT treated milk. Acoustic wave–based biosensors operated in the thickness shear mode (TSM) showed potential for the detection of proteolysis of β-casein, a milk protein by protease plasmin. An ultra-high frequency device, the electromagnetic piezoelectric acoustic sensor (EMPAS), designed to enhance the sensitivity of TSM, was tested for detection of plasmin at low concentrations. β-casein layers immobilised on the hydrophilic or hydrophobized surfaces of EMPAS quartz discs served as substrate for the enzyme. In contrast with conventional TSM devices, the shearing oscillations in EMPAS are induced contactless, by a magnetic coil located 30 μm below the quartz crystal. This configuration allows the registration of unusually high harmonics (up to the 49th-53rd), thus enhancing the sensitivity of detection. On both surface types, the adsorbed β-casein mass and the stability of the layer was compared, with the result that hydrophobic surfaces provide superior conditions for immobilisation than the hydrophilic case. Consequent proteolysis measurements of these substrate layers were carried out in a broad plasmin concentration range (32 pM–10 nM) in flow mode. Initial reaction rates measured at different enzyme concentrations have been used to construct a calibration curve based on an inverse Michaelis–Menten type equation. The sensitivity of the EMPAS allowed measurements of as low as 32 pM concentration of plasmin, reaching (and often exceeding) levels comparable to state of the art techniques like ELISA. The presented method however, unlike ELISA, is effective on a timescale of minutes.",
keywords = "Electromagnetic piezoelectric acoustic sensor, Inverse Michaelis–Menten equation, Plasmin, β-casein",
author = "Lor{\'a}nd Rom{\'a}nszki and Marek Tatarko and Mengchi Jiao and Z. Keresztes and Tibor Hianik and Michael Thompson",
year = "2018",
month = "12",
day = "1",
doi = "10.1016/j.snb.2018.08.025",
language = "English",
volume = "275",
pages = "206--214",
journal = "Sensors and Actuators, B: Chemical",
issn = "0925-4005",
publisher = "Elsevier",

}

TY - JOUR

T1 - Casein probe–based fast plasmin determination in the picomolar range by an ultra-high frequency acoustic wave biosensor

AU - Románszki, Loránd

AU - Tatarko, Marek

AU - Jiao, Mengchi

AU - Keresztes, Z.

AU - Hianik, Tibor

AU - Thompson, Michael

PY - 2018/12/1

Y1 - 2018/12/1

N2 - Detection of residual plasmin activity in milk represents a difficult challenge for the dairy industry. Conventional methods are either too expensive or incapable of providing enough data from UHT treated milk. Acoustic wave–based biosensors operated in the thickness shear mode (TSM) showed potential for the detection of proteolysis of β-casein, a milk protein by protease plasmin. An ultra-high frequency device, the electromagnetic piezoelectric acoustic sensor (EMPAS), designed to enhance the sensitivity of TSM, was tested for detection of plasmin at low concentrations. β-casein layers immobilised on the hydrophilic or hydrophobized surfaces of EMPAS quartz discs served as substrate for the enzyme. In contrast with conventional TSM devices, the shearing oscillations in EMPAS are induced contactless, by a magnetic coil located 30 μm below the quartz crystal. This configuration allows the registration of unusually high harmonics (up to the 49th-53rd), thus enhancing the sensitivity of detection. On both surface types, the adsorbed β-casein mass and the stability of the layer was compared, with the result that hydrophobic surfaces provide superior conditions for immobilisation than the hydrophilic case. Consequent proteolysis measurements of these substrate layers were carried out in a broad plasmin concentration range (32 pM–10 nM) in flow mode. Initial reaction rates measured at different enzyme concentrations have been used to construct a calibration curve based on an inverse Michaelis–Menten type equation. The sensitivity of the EMPAS allowed measurements of as low as 32 pM concentration of plasmin, reaching (and often exceeding) levels comparable to state of the art techniques like ELISA. The presented method however, unlike ELISA, is effective on a timescale of minutes.

AB - Detection of residual plasmin activity in milk represents a difficult challenge for the dairy industry. Conventional methods are either too expensive or incapable of providing enough data from UHT treated milk. Acoustic wave–based biosensors operated in the thickness shear mode (TSM) showed potential for the detection of proteolysis of β-casein, a milk protein by protease plasmin. An ultra-high frequency device, the electromagnetic piezoelectric acoustic sensor (EMPAS), designed to enhance the sensitivity of TSM, was tested for detection of plasmin at low concentrations. β-casein layers immobilised on the hydrophilic or hydrophobized surfaces of EMPAS quartz discs served as substrate for the enzyme. In contrast with conventional TSM devices, the shearing oscillations in EMPAS are induced contactless, by a magnetic coil located 30 μm below the quartz crystal. This configuration allows the registration of unusually high harmonics (up to the 49th-53rd), thus enhancing the sensitivity of detection. On both surface types, the adsorbed β-casein mass and the stability of the layer was compared, with the result that hydrophobic surfaces provide superior conditions for immobilisation than the hydrophilic case. Consequent proteolysis measurements of these substrate layers were carried out in a broad plasmin concentration range (32 pM–10 nM) in flow mode. Initial reaction rates measured at different enzyme concentrations have been used to construct a calibration curve based on an inverse Michaelis–Menten type equation. The sensitivity of the EMPAS allowed measurements of as low as 32 pM concentration of plasmin, reaching (and often exceeding) levels comparable to state of the art techniques like ELISA. The presented method however, unlike ELISA, is effective on a timescale of minutes.

KW - Electromagnetic piezoelectric acoustic sensor

KW - Inverse Michaelis–Menten equation

KW - Plasmin

KW - β-casein

UR - http://www.scopus.com/inward/record.url?scp=85051393359&partnerID=8YFLogxK

UR - http://www.scopus.com/inward/citedby.url?scp=85051393359&partnerID=8YFLogxK

U2 - 10.1016/j.snb.2018.08.025

DO - 10.1016/j.snb.2018.08.025

M3 - Article

AN - SCOPUS:85051393359

VL - 275

SP - 206

EP - 214

JO - Sensors and Actuators, B: Chemical

JF - Sensors and Actuators, B: Chemical

SN - 0925-4005

ER -